Lastec 325D-425D Bedienungsanleitung

Seite laden ...

Drive Unit

Seat Assembly

2

2-4 325D/P/425D/masterdoc062601 Drive Unit

2.2 Seat Assembly

REF DESCRIPTION PART # QTY.

1 SEAT, AIR RIDE P630 1

2Seat Switch P826 1

3Screw, Seat Switch F412 2

4 BELT, SEAT P776 1

5 BOLT, 1/2-13 X 1” HEX HEAD PLAIN F05008-100 2

6 NUT, 1/2-13 NYLON LOCK F05010-8 2

7 PAN WELDMENT, SEAT BOTTOM 019038 1

8 NUT, M8X1.25 HEX JAM F05010-76 4

9 WASHER, 5/16” SPLIT LOCK F05011-13 4

10 SHOCK, SEAT GAS 019088 1

11 NUT, 1/2-13 HALF NYLON HEX LOCK F05010-127 2

12 HINGE WELDMENT, SEAT PAN RIGHT 028246 1

13 HINGE WELDMENT, SEAT PAN LEFT 028247 1

14 NUT, 3/8-16 HALF HEX NYLON LOCK F05010-124 2

15 BOLT, 3/8-16 X 4 1/2” HEX HEAD F05007-35 2

16 WASHER, 3/8” FLAT F05011-3 4

17 WASHER, 3/8” SPLIT LOCK F05011-4 4

18 BOLT, 3/8-16 X 3/4” HEX HEAD GRADE 5 F05007-118 4

19 SPRING, 1/2 X 2 1/4 X .06” EXTENSION 014817 1

20 NUT, 1/4-20 HALF NYLON LOCK F05010-156 1

21 BOLT, 1/4-20 X 1” HEX HEAD GRADE 5 F05005-101 1

22 BOLT, 5/16-18 X 1 1/2” HEX HEAD GRADE 5 F05008-96 2

23 NUT, 5/16-18 NYLON LOCK HEX F05010-58 4

24 SPACER, SEAT SUPPORT REAR 018465 2

25 BOLT, 5/16-18 X 3” HEX HEAD GRADE 5 SELF TAPPING F05006-91 2

26 SPACER, SEAT SUPPORT FRONT 018793 2

27 DECAL, FORWARD/REVERSE MOTION CONTROL P860 2

28 DECAL, THROTTLE EQUIPMENT P835 1

29 DECAL, BELT DIAGRAM 425D 018052 1

DECAL, BELT DIAGRAM 325D 018785 1

30 DECAL, BELT DIAGRAM 325D 018785 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Front Axle/Front Tires Assembly

2

2-6 325D/P/425D/masterdoc062601 Drive Unit

2.3 Front Axle/Front Tires Assembly

REF DESCRIPTION PART # QTY.

1 BOLT, 3/4-16 X 1 1/2” HEX HEAD GRADE 5 F05013-72 1

2 WASHER, 3/4” SPLIT LOCK F05011-6 1

3 WASHER, 3/4” SAE FLAT F05011-1 1

4 PLATE, FRONT AXLE RETAINING 018898 1

5 BUSHING, 1 1/2” ID X 1 3/4” OD X 1 1/2” LONG BRONZE 018894 2

6 SCREW, 3/8-16 X 1” HEX HEAD CAP F05007-7 2

7 WASHER, 3/8” FLAT F05011-3 2

8 NUT, 3/8-16 HEX NYLON LOCK F05010-10 2

9 FITTING, 1/4-28 GREASE P05060 7

10 BOLT, 1/2-13 X 1” HEX HEAD F05008-50 2

11 WASHER, .5 X 1.69 X 11 GAUGE 014632 2

12 BEARING, 6206 25” IDLER P11035 4

13 WHEEL, 15 X 6-6.00 019107 2

14 Cap, Hub P195 1

15 Nut, 3/4-16 Castle P434 1

16 Bearing Washer, 3/4” ID P433 1

17 Bearing, 1” ID Tapered Roller P190 2

18 Bearing Seal, 1 1/4” ID P191 1

19 PIN, 1/8 X 1 1/2” COTTER F05012-49 2

20 YOKE WELDMENT, 13” LEFT 019028 1

21 YOKE WELDMENT, 13” RIGHT 019027 1

22 PIVOT WELDMENT, DECK RAISE 019136 1

23 PLATE, MIDDLE DECK RISER 018890 2

24 AXLE WELDMENT, FRONT DIESEL 018893 1

25 PIN WELDMENT, FRONT PIVOT 028051 1

26 WASHER, 1/4” SPLIT LOCK F05011-14 2

27 BOLT, 1/4-20 X 3/4” HEX HEAD GRADE 5 F05005-123 2

28 PIN WELDMENT, DECK PULL 018473 1

29 BUSHING, 1” ID X 1 1/4” OD FLANGED P109 4

30 SPRING, 1 3/8” X 14” P09426 1

31 NUT, 1/2-13 NYLON LOCK F05010-8 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Taillight Assembly

2

2-10 325D/P/425D/masterdoc062601 Drive Unit

2.5 Taillight Assembly

REF DESCRIPTION PART # QTY.

1 GUARD, REAR LIGHT 019142 2

2 LIGHT ASSEMBLY, HAZARD RED/AMBER 1 WIRE 024398 1

3 SCREW, 3/8-16 X 1 1/4” HEX HEAD CAP F05007-2 4

4 WASHER, 3/8” FLAT F05011-3 8

5 NUT, 3/8-16 HEX NYLON LOCK F05010-10 4

FIG. 2-5

2

3

4

5

D005

1

Go to www.lastec.com for latest changes in this manual.

Drive Unit

Step Assembly

Drive Unit 325D/425D/masterdoc062601 2-11

2

2.6 Step Assembly

REF DESCRIPTION PART # QTY.

1 STEP, RIGHT SIDE 028273 1

2 BOLT, 1/2-13 X 3/4” HEX HEAD FULL THREAD F05008-88 4

3 WASHER, 1/2” SPLIT LOCK F05011-9 4

4 DECAL, STEP 028296 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Emergency Brake Assembly (Serial Numbers 25+)

Drive Unit 325D/425D/masterdoc062601 2-19

2

2.10 Emergency Brake Assembly (Serial Numbers 25+)

REF DESCRIPTION PART # QTY.

1 HANDLE, EMERGENCY BRAKE P622 1

2 BOLT, 3/8-16 X 2” FULL THREAD HEX HEAD F05007-16 2

3 SPACER, 13/32 ID X 3/4 OD X 7/16” STEEL 028109 2

4 NUT, 3/8-16 HEX F05010-1 2

5 WASHER, 3/8” FLAT F05011-3 2

6 NUT, 3/8-16 HEX NYLON LOCK F05010-10 5

7 GUARD WELDMENT, EMERGENCY BRAKE HANDLE 019178 1

8 BOLT, 3/8-16 X 1 3/4” HEX HEAD F05007-119 1

9 PLATE ASSEMBLY, SWASH N/A 1

10 FLAT, EMERGENCY BRAKE SENSOR 019615 1

11 NUT, 3/8-16 HALF NYLON LOCK F05010-124 1

12 BOLT, 3/8-16 X 1 1/4” HEX HEAD CAP F05007-2 2

13 ROD END, MALE RIGHT-HAND THREAD 018739 1

14 NUT, 3/8-24 HEX JAM F05010-22 3

15 TURNBUCKLE, 2” 018792 1

16 ROD END, MALE LEFT-HAND THREAD 018740 1

17 ROD END, 3/8-24 FEMALE 019079 2

18 ROD, EMERGENCY BRAKE LINK 019144 2

19 BOLT, 3/8-16 X 2 1/2” HEX HEAD F05007-47 1

20 PIVOT WELDMENT 019131 1

21 CABLE ASSEMBLY, REED SWITCH WITH CONNECTOR 024237 1

22 SCREW, 4-40 X 1/2” SLOTTED ROUND HEAD MACHINE F05004-14 4

23 NUT, #4-40 HEX F05010-43 4

24 DECAL, EMERGENCY BRAKE P862 1

25 SWITCH ACTUATOR, PROXIMITY 8000 SERIES 024340 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Emergency Brake Assembly (Serial Numbers Prior to 25)

Drive Unit 325D/425D/masterdoc062601 2-21

2

2.11 Emergency Brake Assembly (Serial Numbers Prior to 25)

REF DESCRIPTION PART # QTY.

1 HANDLE, EMERGENCY BRAKE P622 1

2 BOLT, 3/8-16 X 2” FULL THREAD HEX HEAD F05007-16 2

3 SPACER, 13/32 ID X 3/4 OD X 7/16” STEEL 028109 2

4 NUT, 3/8-16 HEX F05010-1 2

5 WASHER, 3/8” FLAT F05011-3 2

6 NUT, 3/8-16 HEX NYLON LOCK F05010-10 6

PLATE ASSEMBLY, SWASH -- 1

7Plate Weldment, Swash 019132 1

8Ring, 1/2” OR 3100-50 Retaining F04254-18 2

9Shaft, Brake Pull 019116 1

10 FLAT, EMERGENCY BRAKE SENSOR 019615 1

ROD ASSEMBLY, EMERGENCY BRAKE ACTUATOR -- 1

11 Rod End, 3/8-24 Female 019079 1

12 Nut, 3/8-24 UNC hex Jam F05010-22 1

13 Rod, Drive Thread Link 019145 1

14 Rod End, 3/8-24 Female P780 1

15 PIVOT WELDMENT, EMERGENCY BRAKE 019131 1

ROD ASSEMBLY, EMERGENCY BRAKE LINK -- 1

16 Rod End, 3/8-24 Female 019079 1

17 Nut, 3/8-24 UNC Hex Jam F05010-22 1

18 Rod, Emergency Brake Left 019082 1

19 ROD END, 3/8-24 FEMALE P780 1

20 ROD, EMERGENCY BRAKE LINK 019144 1

21 CABLE ASSEMBLY, REED SWITCH WITH CONNECTOR 024237 1

22 SCREW, 4-40 X 1/2” SLOTTED ROUND HEAD MACHINE F05004-14 4

23 NUT, #4-40 HEX F05010-43 4

24 GUARD WELDMENT, EMERGENCY BRAKE HANDLE 019178 1

25 BOLT, 3/8-16 X 1 3/4” HEX HEAD F05007-119 1

26 NUT, 3/8-16 HALF NYLON LOCK F05010-124 1

27 DECAL, EMERGENCY BRAKE P862 1

28 SWITCH ACTUATOR, PROXIMITY 8000 SERIES 024340 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Deck Height Adjustment Assembly (425D Only - Serial Nos. 1541298+)

Drive Unit 325D/425D/masterdoc062601 2-23

2

2.12 Deck Height Adjustment Assembly (425D Only - Serial Nos. 1541298+)

REF DESCRIPTION PART # QTY.

1 BOLT, 3/8-16 X 1 1/2” HEX HEAD F05007-3 3

2 WASHER, 3/8” FLAT F05011-3 6

3 NUT, 3/8-16 HEX F05010-1 3

4 LINK, DECK LIFT LONG 028129 1

5 LINK, DECK LIFT SHORT 028130 2

ARM ASSEMBLY, DECK LIFT -- 1

6Arm Weldment, Deck Left Pivot 028058 1

7Plate, Deck Lift Link 028065 2

8Pin Weldment, Deck Lift Pivot 028063 1

9Washer, 1/4” Split Lock F05011-14 1

10 Bolt, 1/4-20 x 1/2” Hex Head F05005-15 1

11 Arm Weldment, Deck Lift Mount 028059 1

12 Pedal Weldment, Deck Lift 028128 1

13 Bushing, 3/4” ID x 5/8” Long Bronze P403 2

14 Washer, 3/4” SAE Flat Unplated F05011-1 1

15 Pin, 1/8 x 1” Cotter F05012-1 1

16 FITTING, 90° GREASE P04108 1

17 BOLT, 5/16-18 X 1 1/4” HEX HEAD F05009-62 2

18 FITTING, #6 JIC - #8 SAE ELBOW 015907 2

19 VALVE, UP/DOWN 018814 1

20 FITTING, #8 SAE - 1/4NPT ADAPTER 028160 2

21 FITTING, #4 JIC - 1/4NPT 45° ELBOW 028161 2

22 NUT, 5/16-18 NYLON LOCK F05010-58 2

23 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 1

24 NUT, 5/16-18 HEX F05010-17 1

25 CYLINDER, DECK LIFT 028064 1

SEAL KIT 028624 1

26 BOLT, 1/2-13 X 3 1/2” HEX HEAD GRADE 5 F05008-61 2

27 NUT, 1/2-13 NYLON HEX LOCK F05010-8 2

28 BOLT, 1/2-13 X 1” HEX HEAD GRADE 5 F05008-101 4

29 WASHER, 1/2” SPLIT LOCK F05011-9 4

30 PEDAL WELDMENT, DECK RAISE 028284 1

31 SHAFT WELDMENT, DECK HEIGHT ADJUST 019138 1

32 SPACER, 3/8” DECK LIFT 019535 14

33 SPACER, 3/8” DECK LIFT KNURLED 019535-1 4

34 SPRING, 5/8" X 3 1/2" DECK HEIGHT HANDLE 019517 1

35 KNOB, 1 3/8 X 3/8-24 019086 1

36 GRIP, FOOT CONTROL BLACK P629 1

37 PLATE, COVER 019070 1

38 PIN, 3/8” SPRING P650 1

39 YOKE, 3/8-24 P686 1

Go to www.lastec.com for latest changes in this manual.

Drive Unit

Deck Height Adjustment Assembly (425D Only - Serial Nos. 1541298+)

Drive Unit 325D/425D/masterdoc062601 2-24

2

40 NUT, 3/8-24 FREE F05010-123 1

41 PIN, 3/8 X 3 3/4” CLEVIS F05012-72 1

42 PIN, 1/8 X 1 1/2” COTTER F05012-49 1

43 WASHER, 3/8” SAE FLAT F05011-61 1

44 WASHER, 3/8” SPLIT LOCK F05011-4 1

45 DECAL, DECK HEIGHT ADJUSTMENT CONTROL P861 1

46 WASHER, 5/16” SAE FLAT F05011-17 2

47 WASHER, 5/16” SPLIT LOCK F05011-13 2

48 BOLT, 5/16-18 X 3/4” HEX HEAD F05006-5 2

49 BOLT, 3/8-16 X 3” HEX HEAD GRADE 5 F05007-73 1

50 DECAL, EQUIPMENT DECK LIFT 425D 019556 1

51 DECAL, PRESSURE WASHER CAUTION 019559 2

FIG. 2-12

30

41

42

47

12

13 16

14

15

18

23

22

44

22

19

20

21

26

25

1

4

5

12

23

2

23

6

27

8

10

9

11

28

29

17

27

31

32

34

37

45

46

43

36

38 39 40

D011D

35

50

51

33

Go to www.lastec.com for latest changes in this manual.

Drive Unit

Deck Height Adjustment Assembly (425D Only - Serial Nos. Prior to 1530898)

Drive Unit 325D/425D/masterdoc062601 2-25

2

2.13 Deck Height Adjustment Assembly (425D Only - Serial Nos. Prior to

1530898)

REF DESCRIPTION PART # QTY.

1 BOLT, 3/8-16 X 1 1/2” HEX HEAD F05007-3 3

2 WASHER, 3/8” FLAT F05011-3 6

3 NUT, 3/8-16 HEX F05010-1 3

4 LINK, DECK LIFT LONG 028129 1

5 LINK, DECK LIFT SHORT 028130 2

ARM ASSEMBLY, DECK LIFT -- 1

6Arm Weldment, Deck Left Pivot 028058 1

7Plate, Deck Lift Link 028065 2

8Pin Weldment, Deck Lift Pivot 028063 1

9Washer, 1/4” Split Lock F05011-14 1

10 Bolt, 1/4-20 x 1/2” Hex Head F05005-15 1

11 Arm Weldment, Deck Lift Mount 028059 1

12 Pedal Weldment, Deck Lift 028128 1

13 Bushing, 3/4” ID x 5/8” Long Bronze P403 2

14 Washer, 3/4” SAE Flat Unplated F05011-1 1

15 Pin, 1/8 x 1” Cotter F05012-1 1

16 FITTING, 90° GREASE P04108 1

17 BOLT, 5/16-18 X 1 1/4” HEX HEAD F05009-62 2

18 FITTING, #6 JIC - #8 SAE ELBOW 015907 2

19 VALVE, UP/DOWN 018814 1

20 FITTING, #8 SAE - 1/4NPT ADAPTER 028160 2

21 FITTING, #4 JIC - 1/4NPT 45° ELBOW 028161 2

22 NUT, 5/16-18 NYLON LOCK F05010-58 2

23 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 1

24 NUT, 5/16-18 HEX F05010-17 1

25 CYLINDER, DECK LIFT 028064 1

26 BOLT, 1/2-13 X 3 1/2” HEX HEAD GRADE 5 F05008-61 2

27 NUT, 1/2-13 NYLON HEX LOCK F05010-8 2

28 BOLT, 1/2-13 X 1” HEX HEAD GRADE 5 F05008-101 4

29 WASHER, 1/2” SPLIT LOCK F05011-9 4

30 PEDAL WELDMENT, DECK RAISE 028284 1

31 SHAFT WELDMENT, DECK HEIGHT ADJUST 019138 1

32 SPACER, 3/8” DECK LIFT 019535 14

33 SPACER, 3/8” DECK LIFT KNURLED 019535-1 4

34 SPRING, 5/8" X 3 1/2" DECK HEIGHT HANDLE 019517 1

35 KNOB, 1 3/8 X 3/8-24 019086 1

36 GRIP, FOOT CONTROL BLACK P629 1

37 PLATE, COVER 019070 1

38 PIN, 3/8” SPRING P650 1

39 YOKE, 3/8-24 P686 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Deck Stabilizer Assembly (425D Only)

Drive Unit 325D/425D/masterdoc062601 2-29

2

2.15 Deck Stabilizer Assembly (425D Only)

REF DESCRIPTION PART # QTY.

STABILIZER ASSEMBLY, DECK 028226 1

1Mount Weldment, Deck Stabilizer 028225 1

2Bolt, 3/8-16 x 4 3/4” Hex Head Grade 5 F05007-109 2

3Nut, 3/8-16 Hex Nylon Lock F05010-10 2

4Brace Weldment, Deck Stabilizer 028224 1

5Nut, 3/4-10 Nylon Lock F05010-103 1

6End Weldment, 3/4” Rod 028223 1

7Pin, 3/4x2 Clevis, Yzn F05012-50 1

8Pin, #210 Hitch F05012-62 1

FIG. 2-15

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Hydraulic System

Hydraulic System 325D/425D/masterdoc062601 3-1

3

SECTION 3 HYDRAULIC SYSTEM

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Hydraulic System

Hydraulic Pump Assemblies

3

3-6 325D/425D/masterdoc062601 Hydraulic System

3.3 Hydraulic Pump Assemblies

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 BUSHING, L X 17mm BORE SPLIT TAPER 028228 2

2 KEY, 5mm X 5mm X 1-1/8” 018872 2

3 SHEAVE, 6 OD B SECTION 018773 2

4 NUT, 1/2-13 NYLON HEX LOCK F05010-8 8

5 PLATE, DRIVE MOTOR FRONT MOUNT 018732 2

6 BOLT, 1/2-13 X 1 1/2” HEX HEAD GRADE 5 F05008-33 6

7 WASHER, 1/2” SAE FLAT F05011-2 4

8 BOLT, 1/2-13 X 2” HEX HEAD GRADE 5 F05008-102 2

9SPRING, 1 X 7 X .148” WIRE 019303 2

Spring, Extension, 1.203 x 7 1/2 Zc (Left Side Only) P464 1

10 PUMP, HYDRAULIC BDP-21L-103 DRIVE LEFT P823 1

PUMP,HYDROSTATIC BDP-21L-102 (RH) 018750 1

PUMP, HYDRO BDP-21L-203 RIGHT (325D ONLY) P824 1

BELT, BX34 PUMP DRIVE 028082 2

11 PLATE, DRIVE MOTOR REAR MOUNT 018731 2

12 SPACER, 3/8” DECK LIFT 019535 2

13 PLATE, SPRING ATTACHMENT 028294 1

14 FITTING, #6SAE 45° ELBOW (AUXILIARY PUMP PORTS - 425D ONLY) 015489 2

15 BOLT, 1/4-20 X 1 3/4” HEX HEAD GRADE 5 F05005-68 2

16 NUT, 1/4-20 SELF LOCKING F05010-9 2

17 FITTING, #8SAE - 3/8” BARB W/O-RING P831 2

18 BLOCK, DIRECTION ACTUATOR 018810 2

19 BOLT, 1/4-20 X 3/4” FULL THREAD HEX HEAD CAP F05005-1 1

20 FITTING, #8SAE - #12JIC 90° ELBOW 028256 2

21 FITTING, #4 SAE PLUG HEX SOCKET 027996 2

22 NUT, 5/16-18 NYLON LOCK F05010-58 6

23 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 5

24 BOLT, 5/16-18 X 1 1/4” HEX HEAD F05009-62 1

25 TANK, 4 QUART HYDRAULIC FLUID WITH CAP 018876 1

26 Cap, 2 x 3” Fuel P09683 1

27 BOLT, 1/4-20 X 3/4” FULL THREAD HEX HEAD CAP F05005-1 2

28 WASHER, 1/4” SPLIT LOCK F05011-14 2

29 WASHER, 5/16” FLAT F05011-16 2

30 PLATE, HYDRAULIC OIL FILTER 028184 1

31 MANIFOLD, HYDRAULIC WITH FILTER 027997 1

Filter, Hydraulic 25 Micron 027998 1

32 FITTING, 1/2NPT - 5/8” BARB 90° ELBOW 028075 1

33 FITTING, 1/2NPT X 3/8NPT HEX REDUCER 028073 1

34 FITTING, 3/8NPT STREET TEE 028072 1

35 FITTING, 3/8NPT - 3/8 BARB ELBOW P12708 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Hydraulic System

Hydraulic Motor Assemblies

Hydraulic System 325D/425D/masterdoc073013 3-8

3

3.4 Hydraulic Motor Assemblies

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 MOTOR, HYDRAULIC MB29 (FOR SERIAL NUMBERS 1390798+) 018741 2

MOTOR, HYDRAULIC MB22 (FOR SERIAL NUMBERS PRIOR TO 1390798) 018745 2

2 BOLT, 1/2-13 X 5 1/2” HEX HEAD GRADE 5 F05008-28 6

3 NUT, 1/2-13 NYLON HEX LOCK F05010-8 8

4 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 2

5 ROD, EMERGENCY BRAKE 019144 2

6 NUT, 5/16-18 NYLON LOCK HEX F05010-86 2

7 HUB, BRAKE AND DISK (REPLACABLE BRAKE PADS 019551) 018771 2

8Caliper, Brake Clockwise (RIGHT BRAKE ONLY AS SHOWN) P790 1

Caliper, Brake Counter Clockwise (LEFT BRAKE ONLY) P791 1

9 KEY, 5/16 X 1 WOODRUFF #1008 046800 2

10 PIN, 1/8” X 1 1/2” COTTER F05012-49 2

11 FENDER WELDMENT, RIGHT (SHOWN) 019057 1

FENDER WELDMENT, LEFT 019056 1

12 SCREW, 3/8-16 X 1” HEX HEAD CAP F05007-7 4

13 NUT, 3/8-16 HEX NYLON LOCK F05010-10 4

14 WHEEL, TIRE MOWER 13 X 24 018891 2

15 Nut, Castle 028530 1

16 BOLT, 1/2-13 X 5” HEX HEAD GRADE 5 F05008-66 2

17 BOLT, 1/2-20 X 1” GRADE 8 WHEEL LUG F05008-104 5

18 FITTING, 1/2NPT - #10SAE ELBOW 028279 2

19 FITTING, #8NPT - #12JIC FLARED 028280 2

20 FITTING, #12-#10 SAE ELBOW 028281 2

21 WASHER, 3/8” FLAT F05011-3 4

22 GROMMET, 5/8” ID X 7/8” GROOVE DIAMETER 015460 1

1 Part # P682 is no longer being used. It has been directly replaced with 015460 as of Serial # 2561199.

2

Seite laden ...

Engine, Gearbox And Battery Box

Fuel System

4

4-2 325D/425D/masterdoc062601 Engine, Gearbox And Battery Box

x

4.1 Fuel System

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 TANK WELDMENT, FUEL 019100 1

2 SPOUT, FUEL TANK (INCLUDES MOUNTING SCREWS) 019150 1

3 CAP, FUEL TANK WITH INDICATOR 019151 1

4 NUT, 3/8-16 HEX NYLON LOCK F05010-10 2

5 WASHER, 3/8” FLAT F05011-3 2

6 BOLT, 3/8-16 X 4” HEX HEAD GRADE 5 F05007-126 2

7 FITTING, 3/8NPT X 1/4NPT 90° WITH FILTER SCREEN 028274 1

8 FITTING, 1/4NPT X 1/4” HOSE BARB STRAIGHT 028074 1

9 HOSE, FUEL LINE (TO MOTOR) P642 27”

10 HOSE, FUEL LINE P642 8 1/2”

11 VALVE, FUEL LINE SHUT-OFF P851 1

12 HOSE, FUEL LINE (TO FUEL FILTER) P642 8 1/2”

13 MANIFOLD, FUEL FILTER WITH SEPARATOR 018758 1

Filter, 10 Micron Element Racor #R12T 028084 1

Manifold, Fuel Filter 028503 1

Cup, Fuel Filter 028504 1

14 SCREW, 1/4-20 X 1” HEX HEAD CAP F05005-38 2

15 NUT, 1/4-20 NYLON LOCK F05010-69 2

16 FITTING, 1/4NPT X 1/4 HOSE BARB 90° ELBOW (FUEL FILTER) 028157 2

17 HOSE, FUEL LINE (FUEL FILTER TO FUEL PUMP) P642 8 1/2”

18 DECAL, DIESEL FUEL CAUTION 018784 1

19 CLAMP, HOSE P649 6

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Engine Guards

4

4-4 325D/425D/masterdoc062601 Engine, Gearbox And Battery Box

x

4.2 Engine Guards

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 HOOD WELDMENT, ENGINE 028172 1

2 PLATE, SEAT BACK 028169 1

3 SCREW, 10-24 X 1/2” SLOTTED HEX MACHINE F05004-1 8

4 LATCH, FLEXIBLE DRAW 014829 2

5 NUT, #10-24 SELF LOCKING F05010-14 8

6 BOLT, 3/8-16 X 4 1/2” HEX HEAD F05007-35 2

7 NUT, 3/8-16 HEX NYLON LOCK F05010-10 2

8 PLATE, LOWER REAR 028182 1

9 PLATE, HITCH 019048 1

10 BOLT, 3/8-16 X 4” HEX HEAD GRADE 5 F05007-126 6

11 NUT, 3/8-16 HEX NYLON LOCK F05010-10 6

12 GROMMET, 1” ID RUBBER P11765 1

13 GROMMET, 5/8” ID X 7/8” GROOVE DIAMETER P682 1

14 BOLT, 3/8-16 X 1” HEX HEAD GRADE 5 F05007-87 4

15 NUT, 3/8-16 X 1” HEX NYLON LOCK F05010-10 4

16 CABLE ASSEMBLY, HOOD 018765 1

17 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 1

18 NUT, 5/16-18 NYLON LOCK F05010-58 1

19 HANDLE W/BOLTS 028178 1

20 HOLDER, 4” RUBBER DAM 027990 1

21 SHIELD , RUBBER RIGHT BOTTOM 028112 1

22 HOLDER, 20 1/2” RUBBER DAM 027995 1

23 SHIELD, RUBBER BOTTOM 028111 1

24 HOLDER 3 1/2” RUBBER DAM 027991 2

25 SHIELD, RUBBER LEFT BOTTOM 028113 2

26 HOLDER, 7 3/4” RUBBER DAM 027992 1

27 SHIELD, RUBBER RIGHT TOP 028114 1

28 WASHER, 3/8” FLAT F05011-29 4

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Engine Assembly

4

4-6 325D/425D/masterdoc062601 Engine, Gearbox And Battery Box

\

4.3 Engine Assembly

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 ENGINE, 38HP KUBOTA DIESEL 018774 1

Dipstick, Kubota #16611-36410 028512 1

Exhaust Gasket, Kubota #15263-12370 028513 1

Fan Belt, Kubota #16282-97010 028514 1

Filter, Oil Kubota #16271-32090 018050 1

Fuel Injector, Kubota #16032-53000 028515 1

Fuel Injector Gasket, Kubota #15841-53622 028516 1

Fuel Transfer Pump, Kubota #16285-52032 028517 1

Fuel Transfer Pump Gasket, Kubota #16264-52140 028518 1

Gasket Kit, Lower Kubota #07916-29265 028519 1

Gasket Kit, Upper Kubota #16286-99352 028520 1

Glow Plug, Kubota #16851-65512 028521 1

Starter, Kubota #37560-63010 028522 1

Stop Solenoid, Kubota #17454-60010 028523 1

Valve Cover Gasket, Kubota #16241-14520 028524 1

Water Pump, Kubota #16241-73032 028525 1

Water Pump Gasket, Kubota #16259-73430 028526 1

Alternator, Kubota Engine 029553 1

Radiator Fan, Kubota 028662 1

2MUFFLER 019152 1

3 BRACE, MUFFLER 018747 1

4 BOLT, 1/4-20 X 1 1/4” HEX HEAD CAP F05005-3 1

5 CLAMP, MUFFLER 018748 2

6 BOLT, 1/4-20 X 3/4” FULL THREAD HEX HEAD CAP F05005-1 1

7 NUT, 1/4-20 SELF LOCKING F05010-9 2

8 BOLT, 5/16-24 X 1” HEX HEAD F05006-11 4

9 WASHER, 5/16” SPLIT LOCK F05011-13 4

10 CLUTCH, ELECTRIC DOUBLE 018843 1

11 SHEAVE, OUTPUT 028131 1

12 BRACKET, PIVOT CLUTCH STOP 028135 1

13 SCREW, 3/8-16 X 1 1/4” HEX HEAD CAP F05007-2 2

14 BRACKET WELDMENT, CLUTCH STOP 028136 1

15 NUT, 3/8-16 HEX NYLON LOCK F05010-10 2

16 BRACKET, THROTTLE 019009 1

17 BRACE, REAR MUFFLER 028216 1

FILTER, AIR 1 N/A 1

18 Filter, Enginaire Housing 1028397 1

Filter, Air Maze Housing 1028528 1

19 Filter, Pre-Cleaner 1028527 1

Filter, Enginaire E2 Inner Element 1028598 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Radiator Assembly

Engine, Gearbox And Battery Box 325D/425D/masterdoc062601 4-9

4

4.4 Radiator Assembly

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 RADIATOR 028227 1

Cap, Radiator Kubota #15272-72020 028529 1

2 NUT, 3/8-16 HEX NYLON LOCK F05010-10 1

3 BUSHING, RUBBER RADIATOR MOUNT 028217 3

4 SCREW, 3/8-16 X 3/4” HEX HEAD CAP GRADE 5 F05007-147 1

5 BRACKET, RADIATOR TOP 018788 1

6 BOLT, 1/4-20 X 1/2” HEX HEAD F05005-15 16

7 GUARD, RADIATOR TOP 028185 1

8 NUT, 1/4-20 SELF LOCKING F05010-9 6

9 COOLER, HYDRAULIC FLUID 018798 2

10 PLATE, LEFT COOLER MOUNT 028181 1

11 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 6

12 NUT, 5/16-18 NYLON LOCK F05010-58 6

13 BAR, LOW PRESSURE COOLER MOUNT 028213 2

14 PLATE, RIGHT COOLER MOUNT 028180 1

15 WASHER, 1/4” SPLIT LOCK F05011-14 12

16 MOUNT WELDMENT, MOTOR/RADIATOR 018797 1

17 BOLT, 3/8-16 X 3/4” HEX HEAD CAP GRADE 5 F05007-147 2

18 WASHER, 3/8” SPLIT F05011-4 3

19 BOLT, 1/2-13 X 3” HEX HEAD GRADE 5 F05008-23 2

20 WASHER, MOTOR MOUNT 018751 2

21 BUSHING, KUBOTA RUBBER MOUNT 018734 2

22 NUT, 1/2-13 NYLON HEX LOCK F05010-8 23

23 SCREW, M10 X 25mm HEX HEAD GRADE 10.9 F05009-52 6

24 WASHER, 7/16” SPLIT LOCK F05011-48 8

25 SCREW, M10 X 30mm HEX HEAD GRADE 10.9 F81003-25 2

26 FITTING, 1/2 NPT - 5/8 HOSE BARB 45° ELBOW 028079 1

27 FITTING, 1/2 NPT - 5/8 BARB 90° ELBOW 028075 2

28 FITTING, 3/8NPT - 3/8 BARB ELBOW P12708 1

29 FITTING, 3/8 NPT - 3/8 BARB P12724 1

30 FITTING, 3/8 NPT STREET TEE 028072 1

31 FITTING, 1/2NPT X 3/8 NPT HEX REDUCER 028073 1

32 RIVET, 1/8 X 1/2 STAINLESS STEEL POP F04203-5 5

33 HOLDER, 18 1/8” RUBBER 027993 1

34 SHIELD, RUBBER LEFT 028115 1

35 HOLDER, 6” RUBBER 027994 1

36 SHIELD, RUBBER RIGHT 028116 1

37 SHIELD, ALTERNATOR HEAT 028258 1

38 WASHER, 3/8” FLAT F05011-3 1

39 WASHER, 1/4” FLAT F05011-60 2

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Gearbox Assembly

Engine, Gearbox And Battery Box 325D/425D/masterdoc062601 4-11

4

4.5 Gearbox Assembly

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 GEARBOX, 1:1 RIGHT HAND 018786 1

2 SHEAVE, GEARBOX CAST OUTPUT 028137 1

3 BOLT, 5/8-11 X 4 1/2” HEX HEAD GRADE 5 F05009-10 2

4 NUT, 5/8-11 HEX F05010-5 4

5 WASHER, 5/8” SPLIT LOCK F05011-27 2

6 BLOCK WELDMENT, GEARBOX MOUNT LEFT 028211 1

7 BUSHING, BX1 018754 1

8 MOUNT WELDMENT, FRONT ENGINE/GEARBOX 028187 1

9 WASHER, 7/16” SPLIT LOCK F05011-48 5

10 SCREW, M10 X 25 HEX HEAD GRADE 10.9 F05009-52 8

11 BOLT, 1/2-13 X 3” HEX HEAD GRADE 5 F05008-23 4

12 WASHER, MOTOR MOUNT 018751 4

13 BUSHING, KUBOTA RUBBER MOUNT 018734 4

14 NUT, 1/2-13 NYLON HEX LOCK F05010-8 4

15 SCREW, 3/8-16 X 1 1/4” SOCKET HEAD CAP BLACK OXIDE F05007-150 4

16 WASHER, 3/8 STAR LOCK EXTERNAL F05011-36 4

17 BLOCK WELDMENT, GEARBOX MOUNT RIGHT 028210 1

18 SHEAVE, 5V5.2-2SDS 028152 1

19 KEY, 1/4” SQUARE X 1” P724 2

20 WASHER, MOTOR MOUNT 018751 1

21 SCREW, 3/8-24 X 1” SOCKET HEAD CAP BLACK OXIDE F05007-74 1

22 WASHER, 3/8” SPLIT LOCK F05011-4 1

BELT, GOODYEAR INSTA-POWER 85340 GEARBOX DRIVE 028277 2

BOLT, 3/8-16 X 1” (FOR CHAINS TO DECKS D1 AND D3 ON 325D ONLY) F05007-82 2

WASHER, 3/8” FLAT (FOR CHAINS TO DECKS D1 AND D3 ON 325D ONLY) F05011-3 2

Seal, Gearbox Input Shaft, Curtis 019597 1

Seal, Gearbox Output Shaft, Curtis 019598 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Battery Box Assembly

Engine, Gearbox And Battery Box 325D/425D/masterdoc062601 4-13

4

4.6 Battery Box Assembly

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 BOX WELDMENT, BATTERY 019104 1

2 NUT, #10-24 SELF LOCKING F05010-14 4

3 SCREW, 10-24 X 1/2” SLOTTED HEX MACHINE F05004-1 4

4 LATCH, FLEXIBLE DRAW 014829 1

5 BATTERY, 12V 26 SERIES MINIMUM 600 COLD-CRANKING AMPS 028004 1

6BOLT, U 028122 1

7 NUT, 5/16-18 NYLON HEX LOCK F05010-86 2

8 SCREW, 3/8-16 X 1” HEX HEAD CAP F05007-7 2

9 NUT, 3/8-16 HEX NYLON LOCK F05010-10 4

10 BOLT, 3/8-16 X 4” HEX HEAD GRADE 5 F05007-126 2

11 WASHER, 3/8” FLAT F05011-3 2

12 PLATE, GROMMET RETAINER 018416 1

13 BOLT, 1/4-20 X 1/2” HEX HEAD F05005-15 1

14 WASHER, 1/4” SPLIT LOCK F05011-14 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Mower Decks

Mower Decks 325D/425D/masterdoc020604 5-1

5

SECTION 5 MOWER DECKS

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Lastec 325D-425D Bedienungsanleitung

Dieses Handbuch ist auch geeignet für

Lastec 325D-425D Bedienungsanleitung

in anderen Sprachen

Sonstige Unterlagen