Lastec 325D Bedienungsanleitung

Seite laden ...

Drive Unit

Seat Assembly

2

2-4 325D/P/425D/masterdoc062601 Drive Unit

2.2 Seat Assembly

REF DESCRIPTION PART # QTY.

1 SEAT, AIR RIDE P630 1

2Seat Switch P826 1

3Screw, Seat Switch F412 2

4 BELT, SEAT P776 1

5 BOLT, 1/2-13 X 1” HEX HEAD PLAIN F05008-100 2

6 NUT, 1/2-13 NYLON LOCK F05010-8 2

7 PAN WELDMENT, SEAT BOTTOM 019038 1

8 NUT, M8X1.25 HEX JAM F05010-76 4

9 WASHER, 5/16” SPLIT LOCK F05011-13 4

10 SHOCK, SEAT GAS 019088 1

11 NUT, 1/2-13 HALF NYLON HEX LOCK F05010-127 2

12 HINGE WELDMENT, SEAT PAN RIGHT 028246 1

13 HINGE WELDMENT, SEAT PAN LEFT 028247 1

14 NUT, 3/8-16 HALF HEX NYLON LOCK F05010-124 2

15 BOLT, 3/8-16 X 4 1/2” HEX HEAD F05007-35 2

16 WASHER, 3/8” FLAT F05011-3 4

17 WASHER, 3/8” SPLIT LOCK F05011-4 4

18 BOLT, 3/8-16 X 3/4” HEX HEAD GRADE 5 F05007-118 4

19 SPRING, 1/2 X 2 1/4 X .06” EXTENSION 014817 1

20 NUT, 1/4-20 HALF NYLON LOCK F05010-156 1

21 BOLT, 1/4-20 X 1” HEX HEAD GRADE 5 F05005-101 1

22 BOLT, 5/16-18 X 1 1/2” HEX HEAD GRADE 5 F05008-96 2

23 NUT, 5/16-18 NYLON LOCK HEX F05010-58 4

24 SPACER, SEAT SUPPORT REAR 018465 2

25 BOLT, 5/16-18 X 3” HEX HEAD GRADE 5 SELF TAPPING F05006-91 2

26 SPACER, SEAT SUPPORT FRONT 018793 2

27 DECAL, FORWARD/REVERSE MOTION CONTROL P860 2

28 DECAL, THROTTLE EQUIPMENT P835 1

29 DECAL, BELT DIAGRAM 425D 018052 1

DECAL, BELT DIAGRAM 325D 018785 1

30 DECAL, BELT DIAGRAM 325D 018785 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Front Axle/Front Tires Assembly

2

2-6 325D/P/425D/masterdoc062601 Drive Unit

2.3 Front Axle/Front Tires Assembly

REF DESCRIPTION PART # QTY.

1 BOLT, 3/4-16 X 1 1/2” HEX HEAD GRADE 5 F05013-72 1

2 WASHER, 3/4” SPLIT LOCK F05011-6 1

3 WASHER, 3/4” SAE FLAT F05011-1 1

4 PLATE, FRONT AXLE RETAINING 018898 1

5 BUSHING, 1 1/2” ID X 1 3/4” OD X 1 1/2” LONG BRONZE 018894 2

6 SCREW, 3/8-16 X 1” HEX HEAD CAP F05007-7 2

7 WASHER, 3/8” FLAT F05011-3 2

8 NUT, 3/8-16 HEX NYLON LOCK F05010-10 2

9 FITTING, 1/4-28 GREASE P05060 7

10 BOLT, 1/2-13 X 1” HEX HEAD F05008-50 2

11 WASHER, .5 X 1.69 X 11 GAUGE 014632 2

12 BEARING, 6206 25” IDLER P11035 4

13 WHEEL, 15 X 6-6.00 019107 2

14 Cap, Hub P195 1

15 Nut, 3/4-16 Castle P434 1

16 Bearing Washer, 3/4” ID P433 1

17 Bearing, 1” ID Tapered Roller P190 2

18 Bearing Seal, 1 1/4” ID P191 1

19 PIN, 1/8 X 1 1/2” COTTER F05012-49 2

20 YOKE WELDMENT, 13” LEFT 019028 1

21 YOKE WELDMENT, 13” RIGHT 019027 1

22 PIVOT WELDMENT, DECK RAISE 019136 1

23 PLATE, MIDDLE DECK RISER 018890 2

24 AXLE WELDMENT, FRONT DIESEL 018893 1

25 PIN WELDMENT, FRONT PIVOT 028051 1

26 WASHER, 1/4” SPLIT LOCK F05011-14 2

27 BOLT, 1/4-20 X 3/4” HEX HEAD GRADE 5 F05005-123 2

28 PIN WELDMENT, DECK PULL 018473 1

29 BUSHING, 1” ID X 1 1/4” OD FLANGED P109 4

30 SPRING, 1 3/8” X 14” P09426 1

31 NUT, 1/2-13 NYLON LOCK F05010-8 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Taillight Assembly

2

2-10 325D/P/425D/masterdoc062601 Drive Unit

2.5 Taillight Assembly

REF DESCRIPTION PART # QTY.

1 GUARD, REAR LIGHT 019142 2

2 LIGHT ASSEMBLY, HAZARD RED/AMBER 1 WIRE 024398 1

3 SCREW, 3/8-16 X 1 1/4” HEX HEAD CAP F05007-2 4

4 WASHER, 3/8” FLAT F05011-3 8

5 NUT, 3/8-16 HEX NYLON LOCK F05010-10 4

FIG. 2-5

2

3

4

5

D005

1

Go to www.lastec.com for latest changes in this manual.

Drive Unit

Step Assembly

Drive Unit 325D/425D/masterdoc062601 2-11

2

2.6 Step Assembly

REF DESCRIPTION PART # QTY.

1 STEP, RIGHT SIDE 028273 1

2 BOLT, 1/2-13 X 3/4” HEX HEAD FULL THREAD F05008-88 4

3 WASHER, 1/2” SPLIT LOCK F05011-9 4

4 DECAL, STEP 028296 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Emergency Brake Assembly (Serial Numbers 25+)

Drive Unit 325D/425D/masterdoc062601 2-19

2

2.10 Emergency Brake Assembly (Serial Numbers 25+)

REF DESCRIPTION PART # QTY.

1 HANDLE, EMERGENCY BRAKE P622 1

2 BOLT, 3/8-16 X 2” FULL THREAD HEX HEAD F05007-16 2

3 SPACER, 13/32 ID X 3/4 OD X 7/16” STEEL 028109 2

4 NUT, 3/8-16 HEX F05010-1 2

5 WASHER, 3/8” FLAT F05011-3 2

6 NUT, 3/8-16 HEX NYLON LOCK F05010-10 5

7 GUARD WELDMENT, EMERGENCY BRAKE HANDLE 019178 1

8 BOLT, 3/8-16 X 1 3/4” HEX HEAD F05007-119 1

9 PLATE ASSEMBLY, SWASH N/A 1

10 FLAT, EMERGENCY BRAKE SENSOR 019615 1

11 NUT, 3/8-16 HALF NYLON LOCK F05010-124 1

12 BOLT, 3/8-16 X 1 1/4” HEX HEAD CAP F05007-2 2

13 ROD END, MALE RIGHT-HAND THREAD 018739 1

14 NUT, 3/8-24 HEX JAM F05010-22 3

15 TURNBUCKLE, 2” 018792 1

16 ROD END, MALE LEFT-HAND THREAD 018740 1

17 ROD END, 3/8-24 FEMALE 019079 2

18 ROD, EMERGENCY BRAKE LINK 019144 2

19 BOLT, 3/8-16 X 2 1/2” HEX HEAD F05007-47 1

20 PIVOT WELDMENT 019131 1

21 CABLE ASSEMBLY, REED SWITCH WITH CONNECTOR 024237 1

22 SCREW, 4-40 X 1/2” SLOTTED ROUND HEAD MACHINE F05004-14 4

23 NUT, #4-40 HEX F05010-43 4

24 DECAL, EMERGENCY BRAKE P862 1

25 SWITCH ACTUATOR, PROXIMITY 8000 SERIES 024340 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Emergency Brake Assembly (Serial Numbers Prior to 25)

Drive Unit 325D/425D/masterdoc062601 2-21

2

2.11 Emergency Brake Assembly (Serial Numbers Prior to 25)

REF DESCRIPTION PART # QTY.

1 HANDLE, EMERGENCY BRAKE P622 1

2 BOLT, 3/8-16 X 2” FULL THREAD HEX HEAD F05007-16 2

3 SPACER, 13/32 ID X 3/4 OD X 7/16” STEEL 028109 2

4 NUT, 3/8-16 HEX F05010-1 2

5 WASHER, 3/8” FLAT F05011-3 2

6 NUT, 3/8-16 HEX NYLON LOCK F05010-10 6

PLATE ASSEMBLY, SWASH -- 1

7Plate Weldment, Swash 019132 1

8Ring, 1/2” OR 3100-50 Retaining F04254-18 2

9Shaft, Brake Pull 019116 1

10 FLAT, EMERGENCY BRAKE SENSOR 019615 1

ROD ASSEMBLY, EMERGENCY BRAKE ACTUATOR -- 1

11 Rod End, 3/8-24 Female 019079 1

12 Nut, 3/8-24 UNC hex Jam F05010-22 1

13 Rod, Drive Thread Link 019145 1

14 Rod End, 3/8-24 Female P780 1

15 PIVOT WELDMENT, EMERGENCY BRAKE 019131 1

ROD ASSEMBLY, EMERGENCY BRAKE LINK -- 1

16 Rod End, 3/8-24 Female 019079 1

17 Nut, 3/8-24 UNC Hex Jam F05010-22 1

18 Rod, Emergency Brake Left 019082 1

19 ROD END, 3/8-24 FEMALE P780 1

20 ROD, EMERGENCY BRAKE LINK 019144 1

21 CABLE ASSEMBLY, REED SWITCH WITH CONNECTOR 024237 1

22 SCREW, 4-40 X 1/2” SLOTTED ROUND HEAD MACHINE F05004-14 4

23 NUT, #4-40 HEX F05010-43 4

24 GUARD WELDMENT, EMERGENCY BRAKE HANDLE 019178 1

25 BOLT, 3/8-16 X 1 3/4” HEX HEAD F05007-119 1

26 NUT, 3/8-16 HALF NYLON LOCK F05010-124 1

27 DECAL, EMERGENCY BRAKE P862 1

28 SWITCH ACTUATOR, PROXIMITY 8000 SERIES 024340 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Deck Height Adjustment Assembly (425D Only - Serial Nos. 1541298+)

Drive Unit 325D/425D/masterdoc062601 2-23

2

2.12 Deck Height Adjustment Assembly (425D Only - Serial Nos. 1541298+)

REF DESCRIPTION PART # QTY.

1 BOLT, 3/8-16 X 1 1/2” HEX HEAD F05007-3 3

2 WASHER, 3/8” FLAT F05011-3 6

3 NUT, 3/8-16 HEX F05010-1 3

4 LINK, DECK LIFT LONG 028129 1

5 LINK, DECK LIFT SHORT 028130 2

ARM ASSEMBLY, DECK LIFT -- 1

6Arm Weldment, Deck Left Pivot 028058 1

7Plate, Deck Lift Link 028065 2

8Pin Weldment, Deck Lift Pivot 028063 1

9Washer, 1/4” Split Lock F05011-14 1

10 Bolt, 1/4-20 x 1/2” Hex Head F05005-15 1

11 Arm Weldment, Deck Lift Mount 028059 1

12 Pedal Weldment, Deck Lift 028128 1

13 Bushing, 3/4” ID x 5/8” Long Bronze P403 2

14 Washer, 3/4” SAE Flat Unplated F05011-1 1

15 Pin, 1/8 x 1” Cotter F05012-1 1

16 FITTING, 90° GREASE P04108 1

17 BOLT, 5/16-18 X 1 1/4” HEX HEAD F05009-62 2

18 FITTING, #6 JIC - #8 SAE ELBOW 015907 2

19 VALVE, UP/DOWN 018814 1

20 FITTING, #8 SAE - 1/4NPT ADAPTER 028160 2

21 FITTING, #4 JIC - 1/4NPT 45° ELBOW 028161 2

22 NUT, 5/16-18 NYLON LOCK F05010-58 2

23 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 1

24 NUT, 5/16-18 HEX F05010-17 1

25 CYLINDER, DECK LIFT 028064 1

SEAL KIT 028624 1

26 BOLT, 1/2-13 X 3 1/2” HEX HEAD GRADE 5 F05008-61 2

27 NUT, 1/2-13 NYLON HEX LOCK F05010-8 2

28 BOLT, 1/2-13 X 1” HEX HEAD GRADE 5 F05008-101 4

29 WASHER, 1/2” SPLIT LOCK F05011-9 4

30 PEDAL WELDMENT, DECK RAISE 028284 1

31 SHAFT WELDMENT, DECK HEIGHT ADJUST 019138 1

32 SPACER, 3/8” DECK LIFT 019535 14

33 SPACER, 3/8” DECK LIFT KNURLED 019535-1 4

34 SPRING, 5/8" X 3 1/2" DECK HEIGHT HANDLE 019517 1

35 KNOB, 1 3/8 X 3/8-24 019086 1

36 GRIP, FOOT CONTROL BLACK P629 1

37 PLATE, COVER 019070 1

38 PIN, 3/8” SPRING P650 1

39 YOKE, 3/8-24 P686 1

Go to www.lastec.com for latest changes in this manual.

Drive Unit

Deck Height Adjustment Assembly (425D Only - Serial Nos. 1541298+)

Drive Unit 325D/425D/masterdoc062601 2-24

2

40 NUT, 3/8-24 FREE F05010-123 1

41 PIN, 3/8 X 3 3/4” CLEVIS F05012-72 1

42 PIN, 1/8 X 1 1/2” COTTER F05012-49 1

43 WASHER, 3/8” SAE FLAT F05011-61 1

44 WASHER, 3/8” SPLIT LOCK F05011-4 1

45 DECAL, DECK HEIGHT ADJUSTMENT CONTROL P861 1

46 WASHER, 5/16” SAE FLAT F05011-17 2

47 WASHER, 5/16” SPLIT LOCK F05011-13 2

48 BOLT, 5/16-18 X 3/4” HEX HEAD F05006-5 2

49 BOLT, 3/8-16 X 3” HEX HEAD GRADE 5 F05007-73 1

50 DECAL, EQUIPMENT DECK LIFT 425D 019556 1

51 DECAL, PRESSURE WASHER CAUTION 019559 2

FIG. 2-12

30

41

42

47

12

13 16

14

15

18

23

22

44

22

19

20

21

26

25

1

4

5

12

23

2

23

6

27

8

10

9

11

28

29

17

27

31

32

34

37

45

46

43

36

38 39 40

D011D

35

50

51

33

Go to www.lastec.com for latest changes in this manual.

Drive Unit

Deck Height Adjustment Assembly (425D Only - Serial Nos. Prior to 1530898)

Drive Unit 325D/425D/masterdoc062601 2-25

2

2.13 Deck Height Adjustment Assembly (425D Only - Serial Nos. Prior to

1530898)

REF DESCRIPTION PART # QTY.

1 BOLT, 3/8-16 X 1 1/2” HEX HEAD F05007-3 3

2 WASHER, 3/8” FLAT F05011-3 6

3 NUT, 3/8-16 HEX F05010-1 3

4 LINK, DECK LIFT LONG 028129 1

5 LINK, DECK LIFT SHORT 028130 2

ARM ASSEMBLY, DECK LIFT -- 1

6Arm Weldment, Deck Left Pivot 028058 1

7Plate, Deck Lift Link 028065 2

8Pin Weldment, Deck Lift Pivot 028063 1

9Washer, 1/4” Split Lock F05011-14 1

10 Bolt, 1/4-20 x 1/2” Hex Head F05005-15 1

11 Arm Weldment, Deck Lift Mount 028059 1

12 Pedal Weldment, Deck Lift 028128 1

13 Bushing, 3/4” ID x 5/8” Long Bronze P403 2

14 Washer, 3/4” SAE Flat Unplated F05011-1 1

15 Pin, 1/8 x 1” Cotter F05012-1 1

16 FITTING, 90° GREASE P04108 1

17 BOLT, 5/16-18 X 1 1/4” HEX HEAD F05009-62 2

18 FITTING, #6 JIC - #8 SAE ELBOW 015907 2

19 VALVE, UP/DOWN 018814 1

20 FITTING, #8 SAE - 1/4NPT ADAPTER 028160 2

21 FITTING, #4 JIC - 1/4NPT 45° ELBOW 028161 2

22 NUT, 5/16-18 NYLON LOCK F05010-58 2

23 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 1

24 NUT, 5/16-18 HEX F05010-17 1

25 CYLINDER, DECK LIFT 028064 1

26 BOLT, 1/2-13 X 3 1/2” HEX HEAD GRADE 5 F05008-61 2

27 NUT, 1/2-13 NYLON HEX LOCK F05010-8 2

28 BOLT, 1/2-13 X 1” HEX HEAD GRADE 5 F05008-101 4

29 WASHER, 1/2” SPLIT LOCK F05011-9 4

30 PEDAL WELDMENT, DECK RAISE 028284 1

31 SHAFT WELDMENT, DECK HEIGHT ADJUST 019138 1

32 SPACER, 3/8” DECK LIFT 019535 14

33 SPACER, 3/8” DECK LIFT KNURLED 019535-1 4

34 SPRING, 5/8" X 3 1/2" DECK HEIGHT HANDLE 019517 1

35 KNOB, 1 3/8 X 3/8-24 019086 1

36 GRIP, FOOT CONTROL BLACK P629 1

37 PLATE, COVER 019070 1

38 PIN, 3/8” SPRING P650 1

39 YOKE, 3/8-24 P686 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Drive Unit

Deck Stabilizer Assembly (425D Only)

Drive Unit 325D/425D/masterdoc062601 2-29

2

2.15 Deck Stabilizer Assembly (425D Only)

REF DESCRIPTION PART # QTY.

STABILIZER ASSEMBLY, DECK 028226 1

1Mount Weldment, Deck Stabilizer 028225 1

2Bolt, 3/8-16 x 4 3/4” Hex Head Grade 5 F05007-109 2

3Nut, 3/8-16 Hex Nylon Lock F05010-10 2

4Brace Weldment, Deck Stabilizer 028224 1

5Nut, 3/4-10 Nylon Lock F05010-103 1

6End Weldment, 3/4” Rod 028223 1

7Pin, 3/4x2 Clevis, Yzn F05012-50 1

8Pin, #210 Hitch F05012-62 1

FIG. 2-15

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Hydraulic System

Hydraulic System 325D/425D/masterdoc062601 3-1

3

SECTION 3 HYDRAULIC SYSTEM

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Hydraulic System

Hydraulic Pump Assemblies

3

3-6 325D/425D/masterdoc062601 Hydraulic System

3.3 Hydraulic Pump Assemblies

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 BUSHING, L X 17mm BORE SPLIT TAPER 028228 2

2 KEY, 5mm X 5mm X 1-1/8” 018872 2

3 SHEAVE, 6 OD B SECTION 018773 2

4 NUT, 1/2-13 NYLON HEX LOCK F05010-8 8

5 PLATE, DRIVE MOTOR FRONT MOUNT 018732 2

6 BOLT, 1/2-13 X 1 1/2” HEX HEAD GRADE 5 F05008-33 6

7 WASHER, 1/2” SAE FLAT F05011-2 4

8 BOLT, 1/2-13 X 2” HEX HEAD GRADE 5 F05008-102 2

9SPRING, 1 X 7 X .148” WIRE 019303 2

Spring, Extension, 1.203 x 7 1/2 Zc (Left Side Only) P464 1

10 PUMP, HYDRAULIC BDP-21L-103 DRIVE LEFT P823 1

PUMP,HYDROSTATIC BDP-21L-102 (RH) 018750 1

PUMP, HYDRO BDP-21L-203 RIGHT (325D ONLY) P824 1

BELT, BX34 PUMP DRIVE 028082 2

11 PLATE, DRIVE MOTOR REAR MOUNT 018731 2

12 SPACER, 3/8” DECK LIFT 019535 2

13 PLATE, SPRING ATTACHMENT 028294 1

14 FITTING, #6SAE 45° ELBOW (AUXILIARY PUMP PORTS - 425D ONLY) 015489 2

15 BOLT, 1/4-20 X 1 3/4” HEX HEAD GRADE 5 F05005-68 2

16 NUT, 1/4-20 SELF LOCKING F05010-9 2

17 FITTING, #8SAE - 3/8” BARB W/O-RING P831 2

18 BLOCK, DIRECTION ACTUATOR 018810 2

19 BOLT, 1/4-20 X 3/4” FULL THREAD HEX HEAD CAP F05005-1 1

20 FITTING, #8SAE - #12JIC 90° ELBOW 028256 2

21 FITTING, #4 SAE PLUG HEX SOCKET 027996 2

22 NUT, 5/16-18 NYLON LOCK F05010-58 6

23 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 5

24 BOLT, 5/16-18 X 1 1/4” HEX HEAD F05009-62 1

25 TANK, 4 QUART HYDRAULIC FLUID WITH CAP 018876 1

26 Cap, 2 x 3” Fuel P09683 1

27 BOLT, 1/4-20 X 3/4” FULL THREAD HEX HEAD CAP F05005-1 2

28 WASHER, 1/4” SPLIT LOCK F05011-14 2

29 WASHER, 5/16” FLAT F05011-16 2

30 PLATE, HYDRAULIC OIL FILTER 028184 1

31 MANIFOLD, HYDRAULIC WITH FILTER 027997 1

Filter, Hydraulic 25 Micron 027998 1

32 FITTING, 1/2NPT - 5/8” BARB 90° ELBOW 028075 1

33 FITTING, 1/2NPT X 3/8NPT HEX REDUCER 028073 1

34 FITTING, 3/8NPT STREET TEE 028072 1

35 FITTING, 3/8NPT - 3/8 BARB ELBOW P12708 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Hydraulic System

Hydraulic Motor Assemblies

Hydraulic System 325D/425D/masterdoc073013 3-8

3

3.4 Hydraulic Motor Assemblies

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 MOTOR, HYDRAULIC MB29 (FOR SERIAL NUMBERS 1390798+) 018741 2

MOTOR, HYDRAULIC MB22 (FOR SERIAL NUMBERS PRIOR TO 1390798) 018745 2

2 BOLT, 1/2-13 X 5 1/2” HEX HEAD GRADE 5 F05008-28 6

3 NUT, 1/2-13 NYLON HEX LOCK F05010-8 8

4 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 2

5 ROD, EMERGENCY BRAKE 019144 2

6 NUT, 5/16-18 NYLON LOCK HEX F05010-86 2

7 HUB, BRAKE AND DISK (REPLACABLE BRAKE PADS 019551) 018771 2

8Caliper, Brake Clockwise (RIGHT BRAKE ONLY AS SHOWN) P790 1

Caliper, Brake Counter Clockwise (LEFT BRAKE ONLY) P791 1

9 KEY, 5/16 X 1 WOODRUFF #1008 046800 2

10 PIN, 1/8” X 1 1/2” COTTER F05012-49 2

11 FENDER WELDMENT, RIGHT (SHOWN) 019057 1

FENDER WELDMENT, LEFT 019056 1

12 SCREW, 3/8-16 X 1” HEX HEAD CAP F05007-7 4

13 NUT, 3/8-16 HEX NYLON LOCK F05010-10 4

14 WHEEL, TIRE MOWER 13 X 24 018891 2

15 Nut, Castle 028530 1

16 BOLT, 1/2-13 X 5” HEX HEAD GRADE 5 F05008-66 2

17 BOLT, 1/2-20 X 1” GRADE 8 WHEEL LUG F05008-104 5

18 FITTING, 1/2NPT - #10SAE ELBOW 028279 2

19 FITTING, #8NPT - #12JIC FLARED 028280 2

20 FITTING, #12-#10 SAE ELBOW 028281 2

21 WASHER, 3/8” FLAT F05011-3 4

22 GROMMET, 5/8” ID X 7/8” GROOVE DIAMETER 015460 1

1 Part # P682 is no longer being used. It has been directly replaced with 015460 as of Serial # 2561199.

2

Seite laden ...

Engine, Gearbox And Battery Box

Fuel System

4

4-2 325D/425D/masterdoc062601 Engine, Gearbox And Battery Box

x

4.1 Fuel System

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 TANK WELDMENT, FUEL 019100 1

2 SPOUT, FUEL TANK (INCLUDES MOUNTING SCREWS) 019150 1

3 CAP, FUEL TANK WITH INDICATOR 019151 1

4 NUT, 3/8-16 HEX NYLON LOCK F05010-10 2

5 WASHER, 3/8” FLAT F05011-3 2

6 BOLT, 3/8-16 X 4” HEX HEAD GRADE 5 F05007-126 2

7 FITTING, 3/8NPT X 1/4NPT 90° WITH FILTER SCREEN 028274 1

8 FITTING, 1/4NPT X 1/4” HOSE BARB STRAIGHT 028074 1

9 HOSE, FUEL LINE (TO MOTOR) P642 27”

10 HOSE, FUEL LINE P642 8 1/2”

11 VALVE, FUEL LINE SHUT-OFF P851 1

12 HOSE, FUEL LINE (TO FUEL FILTER) P642 8 1/2”

13 MANIFOLD, FUEL FILTER WITH SEPARATOR 018758 1

Filter, 10 Micron Element Racor #R12T 028084 1

Manifold, Fuel Filter 028503 1

Cup, Fuel Filter 028504 1

14 SCREW, 1/4-20 X 1” HEX HEAD CAP F05005-38 2

15 NUT, 1/4-20 NYLON LOCK F05010-69 2

16 FITTING, 1/4NPT X 1/4 HOSE BARB 90° ELBOW (FUEL FILTER) 028157 2

17 HOSE, FUEL LINE (FUEL FILTER TO FUEL PUMP) P642 8 1/2”

18 DECAL, DIESEL FUEL CAUTION 018784 1

19 CLAMP, HOSE P649 6

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Engine Guards

4

4-4 325D/425D/masterdoc062601 Engine, Gearbox And Battery Box

x

4.2 Engine Guards

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 HOOD WELDMENT, ENGINE 028172 1

2 PLATE, SEAT BACK 028169 1

3 SCREW, 10-24 X 1/2” SLOTTED HEX MACHINE F05004-1 8

4 LATCH, FLEXIBLE DRAW 014829 2

5 NUT, #10-24 SELF LOCKING F05010-14 8

6 BOLT, 3/8-16 X 4 1/2” HEX HEAD F05007-35 2

7 NUT, 3/8-16 HEX NYLON LOCK F05010-10 2

8 PLATE, LOWER REAR 028182 1

9 PLATE, HITCH 019048 1

10 BOLT, 3/8-16 X 4” HEX HEAD GRADE 5 F05007-126 6

11 NUT, 3/8-16 HEX NYLON LOCK F05010-10 6

12 GROMMET, 1” ID RUBBER P11765 1

13 GROMMET, 5/8” ID X 7/8” GROOVE DIAMETER P682 1

14 BOLT, 3/8-16 X 1” HEX HEAD GRADE 5 F05007-87 4

15 NUT, 3/8-16 X 1” HEX NYLON LOCK F05010-10 4

16 CABLE ASSEMBLY, HOOD 018765 1

17 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 1

18 NUT, 5/16-18 NYLON LOCK F05010-58 1

19 HANDLE W/BOLTS 028178 1

20 HOLDER, 4” RUBBER DAM 027990 1

21 SHIELD , RUBBER RIGHT BOTTOM 028112 1

22 HOLDER, 20 1/2” RUBBER DAM 027995 1

23 SHIELD, RUBBER BOTTOM 028111 1

24 HOLDER 3 1/2” RUBBER DAM 027991 2

25 SHIELD, RUBBER LEFT BOTTOM 028113 2

26 HOLDER, 7 3/4” RUBBER DAM 027992 1

27 SHIELD, RUBBER RIGHT TOP 028114 1

28 WASHER, 3/8” FLAT F05011-29 4

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Engine Assembly

4

4-6 325D/425D/masterdoc062601 Engine, Gearbox And Battery Box

\

4.3 Engine Assembly

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 ENGINE, 38HP KUBOTA DIESEL 018774 1

Dipstick, Kubota #16611-36410 028512 1

Exhaust Gasket, Kubota #15263-12370 028513 1

Fan Belt, Kubota #16282-97010 028514 1

Filter, Oil Kubota #16271-32090 018050 1

Fuel Injector, Kubota #16032-53000 028515 1

Fuel Injector Gasket, Kubota #15841-53622 028516 1

Fuel Transfer Pump, Kubota #16285-52032 028517 1

Fuel Transfer Pump Gasket, Kubota #16264-52140 028518 1

Gasket Kit, Lower Kubota #07916-29265 028519 1

Gasket Kit, Upper Kubota #16286-99352 028520 1

Glow Plug, Kubota #16851-65512 028521 1

Starter, Kubota #37560-63010 028522 1

Stop Solenoid, Kubota #17454-60010 028523 1

Valve Cover Gasket, Kubota #16241-14520 028524 1

Water Pump, Kubota #16241-73032 028525 1

Water Pump Gasket, Kubota #16259-73430 028526 1

Alternator, Kubota Engine 029553 1

Radiator Fan, Kubota 028662 1

2MUFFLER 019152 1

3 BRACE, MUFFLER 018747 1

4 BOLT, 1/4-20 X 1 1/4” HEX HEAD CAP F05005-3 1

5 CLAMP, MUFFLER 018748 2

6 BOLT, 1/4-20 X 3/4” FULL THREAD HEX HEAD CAP F05005-1 1

7 NUT, 1/4-20 SELF LOCKING F05010-9 2

8 BOLT, 5/16-24 X 1” HEX HEAD F05006-11 4

9 WASHER, 5/16” SPLIT LOCK F05011-13 4

10 CLUTCH, ELECTRIC DOUBLE 018843 1

11 SHEAVE, OUTPUT 028131 1

12 BRACKET, PIVOT CLUTCH STOP 028135 1

13 SCREW, 3/8-16 X 1 1/4” HEX HEAD CAP F05007-2 2

14 BRACKET WELDMENT, CLUTCH STOP 028136 1

15 NUT, 3/8-16 HEX NYLON LOCK F05010-10 2

16 BRACKET, THROTTLE 019009 1

17 BRACE, REAR MUFFLER 028216 1

FILTER, AIR 1 N/A 1

18 Filter, Enginaire Housing 1028397 1

Filter, Air Maze Housing 1028528 1

19 Filter, Pre-Cleaner 1028527 1

Filter, Enginaire E2 Inner Element 1028598 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Radiator Assembly

Engine, Gearbox And Battery Box 325D/425D/masterdoc062601 4-9

4

4.4 Radiator Assembly

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 RADIATOR 028227 1

Cap, Radiator Kubota #15272-72020 028529 1

2 NUT, 3/8-16 HEX NYLON LOCK F05010-10 1

3 BUSHING, RUBBER RADIATOR MOUNT 028217 3

4 SCREW, 3/8-16 X 3/4” HEX HEAD CAP GRADE 5 F05007-147 1

5 BRACKET, RADIATOR TOP 018788 1

6 BOLT, 1/4-20 X 1/2” HEX HEAD F05005-15 16

7 GUARD, RADIATOR TOP 028185 1

8 NUT, 1/4-20 SELF LOCKING F05010-9 6

9 COOLER, HYDRAULIC FLUID 018798 2

10 PLATE, LEFT COOLER MOUNT 028181 1

11 BOLT, 5/16-18 X 1” HEX HEAD F05006-1 6

12 NUT, 5/16-18 NYLON LOCK F05010-58 6

13 BAR, LOW PRESSURE COOLER MOUNT 028213 2

14 PLATE, RIGHT COOLER MOUNT 028180 1

15 WASHER, 1/4” SPLIT LOCK F05011-14 12

16 MOUNT WELDMENT, MOTOR/RADIATOR 018797 1

17 BOLT, 3/8-16 X 3/4” HEX HEAD CAP GRADE 5 F05007-147 2

18 WASHER, 3/8” SPLIT F05011-4 3

19 BOLT, 1/2-13 X 3” HEX HEAD GRADE 5 F05008-23 2

20 WASHER, MOTOR MOUNT 018751 2

21 BUSHING, KUBOTA RUBBER MOUNT 018734 2

22 NUT, 1/2-13 NYLON HEX LOCK F05010-8 23

23 SCREW, M10 X 25mm HEX HEAD GRADE 10.9 F05009-52 6

24 WASHER, 7/16” SPLIT LOCK F05011-48 8

25 SCREW, M10 X 30mm HEX HEAD GRADE 10.9 F81003-25 2

26 FITTING, 1/2 NPT - 5/8 HOSE BARB 45° ELBOW 028079 1

27 FITTING, 1/2 NPT - 5/8 BARB 90° ELBOW 028075 2

28 FITTING, 3/8NPT - 3/8 BARB ELBOW P12708 1

29 FITTING, 3/8 NPT - 3/8 BARB P12724 1

30 FITTING, 3/8 NPT STREET TEE 028072 1

31 FITTING, 1/2NPT X 3/8 NPT HEX REDUCER 028073 1

32 RIVET, 1/8 X 1/2 STAINLESS STEEL POP F04203-5 5

33 HOLDER, 18 1/8” RUBBER 027993 1

34 SHIELD, RUBBER LEFT 028115 1

35 HOLDER, 6” RUBBER 027994 1

36 SHIELD, RUBBER RIGHT 028116 1

37 SHIELD, ALTERNATOR HEAT 028258 1

38 WASHER, 3/8” FLAT F05011-3 1

39 WASHER, 1/4” FLAT F05011-60 2

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Gearbox Assembly

Engine, Gearbox And Battery Box 325D/425D/masterdoc062601 4-11

4

4.5 Gearbox Assembly

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 GEARBOX, 1:1 RIGHT HAND 018786 1

2 SHEAVE, GEARBOX CAST OUTPUT 028137 1

3 BOLT, 5/8-11 X 4 1/2” HEX HEAD GRADE 5 F05009-10 2

4 NUT, 5/8-11 HEX F05010-5 4

5 WASHER, 5/8” SPLIT LOCK F05011-27 2

6 BLOCK WELDMENT, GEARBOX MOUNT LEFT 028211 1

7 BUSHING, BX1 018754 1

8 MOUNT WELDMENT, FRONT ENGINE/GEARBOX 028187 1

9 WASHER, 7/16” SPLIT LOCK F05011-48 5

10 SCREW, M10 X 25 HEX HEAD GRADE 10.9 F05009-52 8

11 BOLT, 1/2-13 X 3” HEX HEAD GRADE 5 F05008-23 4

12 WASHER, MOTOR MOUNT 018751 4

13 BUSHING, KUBOTA RUBBER MOUNT 018734 4

14 NUT, 1/2-13 NYLON HEX LOCK F05010-8 4

15 SCREW, 3/8-16 X 1 1/4” SOCKET HEAD CAP BLACK OXIDE F05007-150 4

16 WASHER, 3/8 STAR LOCK EXTERNAL F05011-36 4

17 BLOCK WELDMENT, GEARBOX MOUNT RIGHT 028210 1

18 SHEAVE, 5V5.2-2SDS 028152 1

19 KEY, 1/4” SQUARE X 1” P724 2

20 WASHER, MOTOR MOUNT 018751 1

21 SCREW, 3/8-24 X 1” SOCKET HEAD CAP BLACK OXIDE F05007-74 1

22 WASHER, 3/8” SPLIT LOCK F05011-4 1

BELT, GOODYEAR INSTA-POWER 85340 GEARBOX DRIVE 028277 2

BOLT, 3/8-16 X 1” (FOR CHAINS TO DECKS D1 AND D3 ON 325D ONLY) F05007-82 2

WASHER, 3/8” FLAT (FOR CHAINS TO DECKS D1 AND D3 ON 325D ONLY) F05011-3 2

Seal, Gearbox Input Shaft, Curtis 019597 1

Seal, Gearbox Output Shaft, Curtis 019598 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Engine, Gearbox And Battery Box

Battery Box Assembly

Engine, Gearbox And Battery Box 325D/425D/masterdoc062601 4-13

4

4.6 Battery Box Assembly

REF DESCRIPTION ( Indicates Component is Non-saleable) PART # QTY.

1 BOX WELDMENT, BATTERY 019104 1

2 NUT, #10-24 SELF LOCKING F05010-14 4

3 SCREW, 10-24 X 1/2” SLOTTED HEX MACHINE F05004-1 4

4 LATCH, FLEXIBLE DRAW 014829 1

5 BATTERY, 12V 26 SERIES MINIMUM 600 COLD-CRANKING AMPS 028004 1

6BOLT, U 028122 1

7 NUT, 5/16-18 NYLON HEX LOCK F05010-86 2

8 SCREW, 3/8-16 X 1” HEX HEAD CAP F05007-7 2

9 NUT, 3/8-16 HEX NYLON LOCK F05010-10 4

10 BOLT, 3/8-16 X 4” HEX HEAD GRADE 5 F05007-126 2

11 WASHER, 3/8” FLAT F05011-3 2

12 PLATE, GROMMET RETAINER 018416 1

13 BOLT, 1/4-20 X 1/2” HEX HEAD F05005-15 1

14 WASHER, 1/4” SPLIT LOCK F05011-14 1

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Mower Decks

Mower Decks 325D/425D/masterdoc020604 5-1

5

SECTION 5 MOWER DECKS

Go to www.lastec.com for latest changes in this manual.

Seite laden ...

Lastec 325D Bedienungsanleitung

Dieses Handbuch ist auch geeignet für

Lastec 325D Bedienungsanleitung

in anderen Sprachen

Sonstige Unterlagen